SuzukiSavage.com - Newbie with a question and I tried searching!

Welcome, Guest. Please Login or Register :: View Members

SuzukiSavage.com › General Category › Rubber Side Down! › Newbie with a question and I tried searching!

(Moderators: verslagen1, Dave, Serowbot)

‹ Previous topic | Next topic ›

Pages: 1

Newbie with a question and I tried searching! (Read 4 times)

Schmear

Ex Member

Newbie with a question and I tried searching!
03/20/05 at 02:26:16

I found a jardine muffler for my 95 savage. It is the slip on for like 145.00 or so. What do I need to do in order to put it on my bike? Do I need special tools, new gaskets (if so where do I get them), is it a bolt-on part, ect.? Thanks in advance for your help, I have searched and sorted through posts for a few hours now and I cannot find anything.

IP Logged

Savage_Greg Serious Thumper Alliance Member Offline Don't go around your ass to reach your elbow... Posts: 7844 SW Washington State Gender:	Re: Newbie with a question and I tried searching! Reply #1 - 03/20/05 at 07:12:51 Is it a new Jardine? If so, good. Used ones seem to have loose baffles. You can start by removing the old one. Once you have that one off, you'll know how to put on the new one
Back to top	IP Logged

bobo383

Serious Thumper
2004 No Login

Offline

Neck=Red

Posts: 516
Arlington, TX
Gender: male

Re: Newbie with a question and I tried searching!
Reply #2 - 03/20/05 at 07:32:18

Savage_Greg wrote on 12/31/69 at 16:00:03:

You can start by removing the old one. Once you have that one off, you'll know how to put on the new one

Good advice. Even if the Jard is not a perfect fit, Autozone and Pep Boys sell all kinds of exhaust adapters and clamps, cheap. The stock Savage chrome exhaust cover will hide a multitude of sins.

Arlington Texas
Used to have 98 & 88 Savages

IP Logged

Paladin.

Serious Thumper

Offline

Hamster

Posts: 4929
Sunny Southern California
Gender: male

Re: Newbie with a question and I tried searching!
Reply #3 - 03/20/05 at 07:47:11

Just for grins yesterday I removed my muffler. Near where the muffler meets the headpipe there is a 12mm nut and a 10mm nut on a couple of clamps. I loosened both, but the heat shield wouldn't come off. I then noticed a couple of 12mm nuts under the center of the muffler holding it to a bracket. Removed. But the muffler would not lift clear of the barcket until I loosened the two 10mm nuts holding the headpipe to the engine. Then everything wiggled enough to remove the muffler.

Fired it up -- sure is LOUD without a muffler.

Put everything back. Fired it up, still too loud, shut down and tightened the two nuts holding the headpipe to the engine.

Do the Jardine and MAC come with studs in the muffler to fit the same bracket that the stock muffler bolts to?

IP Logged

Savage_Greg Serious Thumper Alliance Member Offline Don't go around your ass to reach your elbow... Posts: 7844 SW Washington State Gender:	Re: Newbie with a question and I tried searching! Reply #4 - 03/20/05 at 07:49:54 Think so....I do know that the SuperTrapp and Raask are Savage specific with stubs for the bracket....
Back to top	IP Logged

Schmear

Ex Member

Re: Newbie with a question and I tried searching!
Reply #5 - 03/20/05 at 09:56:15

bobo383 wrote on 12/31/69 at 16:00:03:

Good advice. Even if the Jard is not a perfect fit, Autozone and Pep Boys sell all kinds of exhaust adapters and clamps, cheap. The stock Savage chrome exhaust cover will hide a multitude of sins.

I am stationed here in Germany and we do not have PEP Boys and Autozone ect.

Is there an online store that sells savage exhaust accessories.

IP Logged

Savage_Rob Serious Thumper Alliance Member Offline Mechanically Inclined Amateur Posts: 6972 Texas (Dallas area) Gender:	Re: Newbie with a question and I tried searching! Reply #6 - 03/20/05 at 17:59:30 The MAC did, yes.
Back to top	1998\|MAC muffler\|ceramic coated header\|K&N air filter\|Amal Mk2 carb\|Odyssey battery\|iridium plug\|NC windshield\|Dunlop 491s\|Superbrace\|EBC brake rotor\|12.5" Progressive shocks\|Kuryakyn ISO grips IP Logged

Pages: 1

‹ Previous topic | Next topic ›

« Home