Home
Forum
Search
Login
Register
Merch
Donate
Welcome, Guest. Please
Login
or
Register
::
View Members
SuzukiSavage.com
›
General Category
›
Rubber Side Down!
› Head Cover Removal - Cam/Tensioner OK?
(Moderators:
verslagen1
,
Dave
,
Serowbot
)
‹
Previous topic
|
Next topic
›
Pages: 1
Head Cover Removal - Cam/Tensioner OK? (Read 15 times)
rokrover
Full Member
2005 No Login
Offline
torkenstein
Posts: 147
SoCal
Head Cover Removal - Cam/Tensioner OK?
12/15/05 at 16:07:14
Wel, my FSM is not in at the dealers yet and my 600mi service is rapidly approaching. Need to retorque the head bolts (and mess with that infamous plug) and that involves removal of the head cover. This cover is the upper bearing shell for the camshaft so my question is: when you remove the head cover does the camshaft pop loose so you got to mess with cam-chain tension adjustment? My hope is it stays in place. Thanks for any feedback; my Clymer manual is rather vague on this point. Also, I assume you can reuse the rubber plug on the cam drive end?
Back to top
IP Logged
torque
Serious Thumper
2005 No Login
Offline
2008 nightster,flat
od green and black
Posts: 748
rock hill,S.C.
Gender:
Re: Head Cover Removal - Cam/Tensioner OK?
Reply #1 -
12/15/05 at 16:32:28
no it wont "pop" loose .
Back to top
IP Logged
Reelthing
Serious Thumper
Alliance Member
Offline
Fish or ride that is
the question
Posts: 5397
Houston,Tx
Gender:
Re: Head Cover Removal - Cam/Tensioner OK?
Reply #2 -
12/15/05 at 16:47:48
be sure and read over the plug tech doc
Back to top
IP Logged
Savage_Rob
Serious Thumper
Alliance Member
Offline
Mechanically
Inclined Amateur
Posts: 6972
Texas (Dallas area)
Gender:
Re: Head Cover Removal - Cam/Tensioner OK?
Reply #3 -
12/16/05 at 05:53:28
And by all means use Greg's advice in the tech section and print an enlarged copy of the bolt hole layout, tape it to a cardboard box and put the bolts into the right holes as you remove them. There are several that are similar but not the same and it would be easy to mix something up. And yes, you can reuse the other plug, though it's more like rubberized metal.
Back to top
1998|MAC muffler|ceramic coated header|K&N air filter|Amal Mk2 carb|Odyssey battery|iridium plug|NC windshield|Dunlop 491s|Superbrace|EBC brake rotor|12.5" Progressive shocks|Kuryakyn ISO grips
IP Logged
Digger
Serious Thumper
2005 No Login
Offline
Ya gotta be tough to
ride singles!
Posts: 1604
Colorado Springs, CO
Gender:
Re: Head Cover Removal - Cam/Tensioner OK?
Reply #4 -
12/16/05 at 08:14:46
I did this job recently.
For the "infamous" plug, be sure you take your time and clean all of the old sealant material from the hole. I didn't do this good enough and had to go back and do it a second time (if this plug is leaking, there will be no doubt you've got an oil leak).
Many (myself included) have had luck with Permatex Ultra Copper gasket sealant.
Also, take notes while you do the job and keep the notes with your FSM. They will help you the next time you do this job.
Back to top
Digger
2001, Metallic Glacial Blue, Raptor Petcock, Verslavy (first hole) (otherwise, mechanically, the bike is stock), 13,xxx miles
I don't own a cage.
www.astronautbiker.com
IP Logged
bentwheel
Serious Thumper
2005 No Login
Offline
Ride free, citizen
Posts: 658
Sarnia, Ontario, Canada
Gender:
Re: Head Cover Removal - Cam/Tensioner OK?
Reply #5 -
12/16/05 at 21:02:59
Another thing to check for when you remove the head cover is oil in the bolt holes. It could cause a hydraulic lock when you torque the cover bolts. Pay close attention to the threads close to the exhaust valve springs as oil from the galley will spill into these holes when the bolt is removed. Several Q Tips will dry up the holes nicely. If you have a tap and die set, chase the threads prior to installation. The threads are 6mm with a 1.0 pitch.
Back to top
Bentwheel FSO
2006 Suzuki 650 V-Strom
1977 Yamaha XS360
1972 Honda CL175
IP Logged
rokrover
Full Member
2005 No Login
Offline
torkenstein
Posts: 147
SoCal
Re: Head Cover Removal - Cam/Tensioner OK?
Reply #6 -
12/17/05 at 16:17:52
Thanks for all the tips - I'll be particularly mindful of the hydraulic lock. So there are four head to crankcase studs, two head to cylinder bolts (fore and aft) and two cylinder to crankcase bolts (right side). Clymer says to remove the four main stud nuts to reoil them for torquing but I always thought you just backed off torque a quarter turn or so but never to zero that freed the gasket causing potential leaks. Besides, all fasteners should be partially relaxed evenly in a criss-cross pattern and that means six bolts for the head. Guess I'll figure it out and maybe it's not so critical. Oh, the curse of being a worry wart!
Back to top
IP Logged
bentwheel
Serious Thumper
2005 No Login
Offline
Ride free, citizen
Posts: 658
Sarnia, Ontario, Canada
Gender:
Re: Head Cover Removal - Cam/Tensioner OK?
Reply #7 -
12/17/05 at 19:23:30
rokrover wrote
on 12/31/69 at 16:00:12:
Clymer says to remove the four main stud nuts to reoil them for torquing but I always thought you just backed off torque a quarter turn or so but never to zero that freed the gasket causing potential leaks. !
I agree with you on this one. I don't like Clymers advice at all. As well the threads should be torqued DRY, adding any thread dressing eg. oil, grease, anti seize, thread locker will increase the torque value by about 20%.
I don't think you are being a worry wart. I would say you are an independent thinker.
Back to top
Bentwheel FSO
2006 Suzuki 650 V-Strom
1977 Yamaha XS360
1972 Honda CL175
IP Logged
Savage_Greg
Serious Thumper
Alliance Member
Offline
Don't go around your
ass to reach your
elbow...
Posts: 7844
SW Washington State
Gender:
Re: Head Cover Removal - Cam/Tensioner OK?
Reply #8 -
12/30/05 at 08:55:41
Wait a minute....of course you don't want to use a "threadlocker" on the nuts. Whoa. Just wait until that stuff has been baked at engine temps and you'd be using a torch to loosen them....
I have done the head nut/stud torquing procedure both ways. Dry and with oil dry....I was also skeptical of the idea of oiling the threads, but after doing so, I understand better.
One little trick here involves the copper washers. During the torquing process the nuts and washers become "seated". The washers are intended to become deformed under the pressure and conform to the head surface while the nut digs into the washer on top. The washers are supposed to be replaced each time too....but who really wants to, or does. Check the used washers and see...they will be gouged. What you can do is get a good flat file, and smooth out the washer surfaces so that the nut will slide on the washer while turning....
Now back to the nuts....use a drop of oil as the book says. Remove and retorque (on the low side) each nut, one at a time, then go around and retorque to the max. in a criss-cross fashion. That way you won't break the head gasket seal....
Why oil? When you do it, you'll see. Oil doesn't increase the torque value, it just makes sure the force is applied in the right direction. Torque is the force exerted to turn the nut. Plain and simple. The purpose of the oil is to make sure the tightening force is applied to the cylinder head and NOT the threads on the dry stud alone....and don't forget that copper washer....the torque is supposed to compress the cylinder head and not be wasted by on trying to turn the washer against the aluminum casting.
And also take the time to clean out all the dirt that gets in the there too.....Think friction. It wastes the torque.
BTW - the right rear head nut is always in an oil bath under the headcover anyway.
Back to top
IP Logged
Pages: 1
‹
Previous topic
|
Next topic
›
Forum Jump »
» 10 most recent posts
» 10 most recent topics
General Category
»» Rubber Side Down!
- Technical Documents/Reference
- The Marketplace
- The Cafe
- Politics, Religion (Tall Table)
- Forum Upgrade Issues / Tests
« Home
« Home
SuzukiSavage.com
12/20/25 at 00:44:15
›
General Category
›
Rubber Side Down!
› Head Cover Removal - Cam/Tensioner OK?
SuzukiSavage.com
» Powered by
YaBB 2.2
!
YaBB
© 2000-2007. All Rights Reserved.