SuzukiSavage.com - Cam Chain Adjuster Life

verslagen1

YaBB Moderator
ModSquad

Offline

Where there's a
will, I want to be
in it.

Posts: 28995
L.A. California
Gender: male

Re: Cam Chain Adjuster Life
Reply #75 - 11/14/10 at 07:28:23

We have 2 high mileage champs, one with a 2002 (35k miles) and another with a 2000 (50k miles). Based on discussions, I think thermal cycling is responsible for accelerated wear then oil.

If you can, review your chart data and give me an estimate of your average trip length. And I'd count a trip with many short stops as one trip if you get back on it before if cools off.

Back to top

Versey's Place
Tech Section Index

IP Logged

Digger

Serious Thumper
2005 No Login

Offline

Ya gotta be tough to
ride singles!

Posts: 1604
Colorado Springs, CO
Gender: male

Re: Cam Chain Adjuster Life
Reply #76 - 11/16/10 at 21:47:09

verslagen1 wrote on 11/14/10 at 07:28:23:

We have 2 high mileage champs, one with a 2002 (35k miles) and another with a 2000 (50k miles). Based on discussions, I think thermal cycling is responsible for accelerated wear then oil.

If you can, review your chart data and give me an estimate of your average trip length. And I'd count a trip with many short stops as one trip if you get back on it before if cools off.

Hi Ver,

Mine is an urban warrior. Average trip length is 10 miles. I ride year 'round here in Colorado Springs, so sometimes I'm sure the engine never gets fully warm when I take it out for just a short hop.

Also, for my chart data, the indication was None and I use 10W40 motor oil.

IHTH!

Back to top

« Last Edit: 08/13/13 at 20:02:13 by Digger »

Digger
2001, Metallic Glacial Blue, Raptor Petcock, Verslavy (first hole) (otherwise, mechanically, the bike is stock), 13,xxx miles
I don't own a cage.
www.astronautbiker.com

IP Logged

ralfyguy Serious Thumper Offline Posts: 932	Re: Cam Chain Adjuster Life Reply #77 - 11/18/10 at 04:48:15 My trip to work is about a little over a mile each way. I ride year around also. Mine is an '06 with 14,000 miles. Modified plunger done at 11,000. I bought the bike at 3,000 miles and the adjuster was out 17mm already. At 11,000 it was at 20.5mm, so I put Verslagen's modified plunger in.
Back to top	IP Logged

buttgoat1

Serious Thumper

Offline

SuzukiSavage.com
Rocks!

Posts: 1042

Re: Cam Chain Adjuster Life
Reply #78 - 11/18/10 at 09:33:59

hmmmm, we have always been told that most wear occurred at startup, and figuring in the heat cycle as a tangent off of that. Your theory does make sense.

That being said, most of my trips were 25+ to work with a good bit of miles put on just beating around. 100 or 2 in a day stopping, but never really letting it cool down much. The PO had a much longer commute to work (50+) if I recall correctly, for the first 4500 miles or so.

That seems counter to the amount of stretch on Betties chain.

Back to top

IP Logged

BurnPgh

Serious Thumper

Offline

SuzukiSavage.com
Rocks!

Posts: 1732

Re: Cam Chain Adjuster Life
Reply #79 - 11/19/10 at 20:42:56

quick acceleration definatively plays a role. I havent accually measured yet, but when replacing my clutch plates i took note that my essentally brand new chain (about 3k mi) was signifcantly "stretched". Id say 14-15mm out from an unused measurement of 8 or 9. Those 3k mi followed my performance mods and needless to say I gun it quite a bit...as in pretty much always.

Back to top

IP Logged

running-it-stock YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 27	Re: Cam Chain Adjuster Life Reply #80 - 06/26/13 at 22:51:18 2007 11,7xx mi new adjuster 17.02mm chain stretch don' know? concerned before long trip/ self assurance nothing since 5k mi -mobil 1 Full Syn. 10w-40. Changed to Rotella @10k mi Rider type- gentle where do you ride the most -freeways Number of Previous Owners? 1
Back to top	IP Logged

SALB Serious Thumper Offline FSO Posts: 668 Whittier, AK Gender:	Re: Cam Chain Adjuster Life Reply #81 - 07/15/13 at 12:06:25 Replace tensioner with verslavy this weekend. 2007 10800 miles tensioner at 17mm did not measure chain, sliders seemed good checked for peace of mind, and it was due by mileage installed is second hole oil - delo dino 15/40 moderate to aggressive rider local and highway 2nd owner???
Back to top	IP Logged

keith YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 37	Re: Cam Chain Adjuster Life Reply #82 - 07/15/13 at 18:29:23 2007 12152 Original just about out of the bore. Opened it because of hearing the problem with it here. atleast 3 other owners.
Back to top	IP Logged

running-it-stock

YaBB Newbies

Offline

SuzukiSavage.com
Rocks!

Posts: 27

Re: Cam Chain Adjuster Life
Reply #83 - 10/26/14 at 19:12:39

running-it-stock wrote on 06/26/13 at 22:51:18:

2007
11,7xx mi
new adjuster
17.02mm
chain stretch don' know?
concerned before long trip/ self assurance
nothing
since 5k mi -mobil 1 Full Syn. 10w-40. Changed to Rotella @10k mi
Rider type- gentle
where do you ride the most -freeways
Number of Previous Owners? 1

Finally got around to changing the cam chain tensioner with verslagan mod.
13216 mi (got a burgman so didn't ride much the last couple years)
18.02 mm

Picture below.

Back to top

« Last Edit: 12/27/14 at 18:41:47 by running-it-stock »

IP Logged

Wake51

Full Member

Offline

Murphy's Law

Posts: 214
St. Louis
Gender: male

Re: Cam Chain Adjuster Life
Reply #84 - 08/08/16 at 10:00:29

2001
14,5XX Miles (2nd Owner Since 5,0XX Miles)
17.5mm Extension, Intend to Install Verslavvy once available
Stock Adjuster
Oil: Rotella T Since Acquired
Riding: Short Commutes During College Years (5-10 mi) Otherwise Lettered Highway and Interstate on 10+ mi trips (65-75mph)
Aggressiveness: Moderate while ringing it out every few rides

My ride seems to be on the mark for reinforcing inspecting the tensioner at 15k, I inspected at 14.5k and I'm sitting .5k short of the recommended 18 mm limit.

Back to top

IP Logged

justin_o_guy2

Serious Thumper

Offline

What happened?

Posts: 55279
East Texas, 1/2 dallas/la.

Re: Cam Chain Adjuster Life
Reply #85 - 08/08/16 at 10:49:15

buttgoat1 wrote on 11/18/10 at 09:33:59:

hmmmm, we have always been told that most wear occurred at startup, and figuring in the heat cycle as a tangent off of that. Your theory does make sense.

That being said, most of my trips were 25+ to work with a good bit of miles put on just beating around. 100 or 2 in a day stopping, but never really letting it cool down much. The PO had a much longer commute to work (50+) if I recall correctly, for the first 4500 miles or so.

That seems counter to the amount of stretch on Betties chain.

WEAR, at start-up is attributed to oil pressure Not being there to protect rotating and sliding parts.
The chain gets tensioned when the cylinder gets taller from heat. If your tensioner just grabbed a tooth on the ratchet then when the cylinder gets hot and grows afew thousandths of an inch it pulls hard on the chain.
That's why the new modification of the added spring that lets the entire tensioner assembly scoot away from the crankshaft a bit helps.

Back to top

The people never give up their liberties but under some delusion.- Edmund Burke.

IP Logged

cheapnewb24 Serious Thumper Offline SuzukiSavage.com Rocks! Posts: 1373 Virginia Gender:	Re: Cam Chain Adjuster Life Reply #86 - 08/08/16 at 22:30:03 I just checked mine today, and it's between 18 and 19.5 mm out, and I have 18k or so. I'll post some pictures in the morning.
Back to top	2004 Suzuki Savage, Riding since fall 2015. IP Logged

Martin K

YaBB Newbies

Offline

I'll have it running
tomorrow...

Posts: 9
Midland, TX
Gender: male

Re: Cam Chain Adjuster Life
Reply #87 - 09/22/18 at 18:20:51

I know it's been a while since any updates on here, but I figured I'd add my 2 cents.

1995
22K miles (probably more, speedo cable was gone when I bought it)
Tensioner at 18mm, seems to be stock
Chain & Sliders are in good shape
Unsure of oil type or riding style. I don't know the previous owner, got the bike through my usual mechanic. Figured I'd check it out while the bike was apart, rather than be surprised a few thousand miles from now.

Martin K

Back to top

Martin K

-95' Savage 650 - Currently under construction

IP Logged

IslandRoad

Serious Thumper

Offline

It doesn't vibrate,
it purrs!

Posts: 1147
The Kiewa Valley, Australia
Gender: male

Re: Cam Chain Adjuster Life
Reply #88 - 12/20/18 at 01:32:38

Year: 2015
Mileage: 16,659
Old or new adjuster: Original
Plunger extension: 14.5mm
Chain stretch: Didn't check
Indications: No indicators - checked the tensioner during oil and filter change
Repair action taken (what did you replace): Oil and filter
Type of Oil? I was using a Motorex synthetic bike oil. I ran the oil low (it took 400mm to top it up) because I skipped a couple of services - long story. I am now using a Penrite product MC-4ST 10W-40 (100% PAO & ESTER)
Rider type: I accelerate hard and then cruise at the speed limit.
Where do you ride the most: Mixed; local jaunts, twisties, and highway. I ran the bike hard while re-jetting - testing acceleration, top speed etc.
Number of Previous Owners? 2; I bought the bike with 1500 kms on it.

Back to top

S40, 2014, Dyna, Raptor, 52.5/152.5, spacer mod, sea level, cat-eye LED tail light, bullet style halogen turn signals, 'Superbars' with custom 40mm risers, modified stock seat, Metzeler tyres.

IP Logged

batman

Serious Thumper

Offline

SuzukiSavage.com
Rocks!

Posts: 3806
osceola new york
Gender: male

Re: Cam Chain Adjuster Life
Reply #89 - 12/23/18 at 19:54:23

1995
19,000 to tensioner extension
35,xxx at present
old
19
127.6
60,000(2mm extension from 19,000 to 35,000)
orig
self-vs type extension,pawl spring removed to stop chain stretch
orig cam chain
dino oil
15w-40
aggr
-all- but less city riding
0
drive train stock except 130/90/15 tire, tuned intake, tuned carb, and Dyna muffler. top speed 90mph.

Back to top

my old work mates called me MacGyver

IP Logged