SuzukiSavage.com - 2017 won't run

cygnet

YaBB Newbies

Offline

SuzukiSavage.com
Rocks!

Posts: 46

2017 won't run
06/22/17 at 10:47:26

Hi Guys i have a new 2017 S40 with 760km's on it. I drove to the gas station yeasterday and as I pulled up to the pump it backfired VERY loudly and stopped. I filled it with gas it only took 5 ltr's and it would not start. I put it on prime and did get it to run but it was running really bad and then it stopped again, and would not start. I had to truck it back to the dealer and have not herd back from them. Any ideas on what is going on? I hate to change anything as I have a 5 year warranty, but I'm not feeling that I have a reliable bike. Angry

Back to top

IP Logged

stewmills Serious Thumper Offline Imagination is more important than knowledge Posts: 2647 Auburn, AL Gender:	Re: 2017 won't run Reply #1 - 06/22/17 at 11:42:28 Although it is new, I am suspicious that it is the petcock diaphragm sticking. That, or a vacuum line not secure or pinched or has a hole in it. Keep us informed what the dealer says. This is a great bike once you get the kinks worked out.
Back to top	2008 \| 152/52.5–Air Mix 3/4 \| Rotella T4 \| Seat Lift w/Sheepskin \| Speedo Rattle \| Rear Pulley Shim \| 140/90-15 Rear \| Kaw Front Pulley \| Relocated Rear Signals FREEDOM ISN'T FREE! IP Logged

Dave

YaBB Moderator
ModSquad

Offline

SuzukiSavage.com
Rocks!

Posts: 18616
Camp Springs, Kentucky
Gender: male

Re: 2017 won't run
Reply #2 - 06/22/17 at 11:44:31

Hard to believe the petcock could fail on a bike so new - but it is possible.

Have them pull the vacuum line on the petcock and see if there is any trace of fuel in it.......that line should be dry. You can shove a golf tee in the vacuum tube, put a cap on the carb nipple, turn the petcock to PRI and see if the bike runs normal again. If it does....and you get the same bad running issue when you hook the vacuum line back up.....then you have confirmed the petcock is faulty.

Back to top

Someday I will be old......But not today!

IP Logged

verslagen1 YaBB Moderator ModSquad Offline Where there's a will, I want to be in it. Posts: 29042 L.A. California Gender:	Re: 2017 won't run Reply #3 - 06/22/17 at 12:19:06 I would suspect something simple, check the petcock, check the vac line, check the gas cap vents, check the carb bowl vents. Bad gas? prime didn't fix it so petcock is low on my list.
Back to top	Versey's Place Tech Section Index IP Logged

jcstokes Serious Thumper Offline SuzukiSavage.com is very useful Posts: 2155 Mauku New Zealand Gender:	Re: 2017 won't run Reply #4 - 06/22/17 at 19:09:06 When it stopped the second time, would the starter work and did you have ignition? Does anything feel loose near the kill switch?
Back to top	Completely stock 2010 S40, aftermarket rev counter and back pack, Airhawk seat pad IP Logged

cygnet YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 46	Re: 2017 won't run Reply #5 - 06/22/17 at 20:29:20 It turned over just fine, but it would not fire. Everything seems tight all hoses on, it's only got 760 km's so all the rubber is soft not tried out.
Back to top	IP Logged

Steve H Serious Thumper Offline SuzukiSavage.com Rocks! Posts: 1223 Spartanburg, SC Gender:	Re: 2017 won't run Reply #6 - 06/23/17 at 09:04:12 Seems too simple and probably already checked but water in the gas? Spark plug?
Back to top	87 LS650, 2005 Ninja 250, 2009 Yamaha C3, 2001 Honda Reflex. On 2 wheels since 6/80. IP Logged

cygnet YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 46	Re: 2017 won't run Reply #7 - 06/23/17 at 16:28:52 Well got the bike back turned out that the negative wire on the coil came un hooked, so I took it for a test drive got 10 miles out of town and the rear tire went flat, so back on the hook, man when it rains it just pours ha ha ha.
Back to top	IP Logged

justin_o_guy2 Serious Thumper Offline What happened? Posts: 55279 East Texas, 1/2 dallas/la.	Re: 2017 won't run Reply #8 - 06/23/17 at 20:14:50 Dayumm,,
Back to top	The people never give up their liberties but under some delusion.- Edmund Burke. IP Logged

Ruttly Serious Thumper Offline Thumpers Rule Posts: 5506 Manteca , CA Gender:	Re: 2017 won't run Reply #9 - 06/23/17 at 20:23:44 Raining LEMON juice !
Back to top	The Topic Terminator IP Logged

jcstokes Serious Thumper Offline SuzukiSavage.com is very useful Posts: 2155 Mauku New Zealand Gender:	Re: 2017 won't run Reply #10 - 06/24/17 at 00:30:28 Actual puncture by something? Or loose valve core or low pressure when it was assembled?
Back to top	Completely stock 2010 S40, aftermarket rev counter and back pack, Airhawk seat pad IP Logged

batman Serious Thumper Offline SuzukiSavage.com Rocks! Posts: 3806 osceola new york Gender:	Re: 2017 won't run Reply #11 - 06/24/17 at 07:17:17 Saving grace is you don't have to look for the problem this time.
Back to top	my old work mates called me MacGyver IP Logged

cygnet YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 46	Re: 2017 won't run Reply #12 - 06/24/17 at 07:53:02 Seems I picked up a small chunk of metal that was on the highway.
Back to top	IP Logged

justin_o_guy2 Serious Thumper Offline What happened? Posts: 55279 East Texas, 1/2 dallas/la.	Re: 2017 won't run Reply #13 - 06/24/17 at 09:19:27 Sorry for your loss. Now might be a good time to put a decent tire on it. If you haul the wheel and get a tire mounted, that's about thirty bucks labor. Take your Bike, let them pull the wheel off and reinstall it and it's gonna Cost Ya,
Back to top	The people never give up their liberties but under some delusion.- Edmund Burke. IP Logged

cygnet YaBB Newbies Offline SuzukiSavage.com Rocks! Posts: 46	Re: 2017 won't run Reply #14 - 06/24/17 at 15:24:19 I just took the wheel in to the shop I also got a new tube so total bill $68.00 Canadian. Put a 100km on today and she ran like a champ and no flat tires so all is good.
Back to top	IP Logged